RE: Panic, when playing music

user113636 — Thu, 16 Jun 2022 09:01:24 GMT

Hi, Karl

after more than 8 hours of test, we got the following message:

$ *** Booting Zephyr OS build v3.0.99-ncs1-rc1 ***
HL [00:00:00.362,426] <dbg> nrf5340_audio_dk_nrf5340_cpuapp: core_config: Setting gpiote latency to r
HL [00:00:00.362,487] <dbg> nrf5340_audio_dk_nrf5340_cpuapp: remoteproc_mgr_boot: Network MCU releas.
HL [00:00:00.367,034] <dbg> main: main: nRF5340 APP core started
HL [00:00:00.367,614] <inf> fw_info:
nRF5340 Audio nRF5340 Audio DK cpuapp
FW Version: 0.5.99
Cmake run : Mon Jun 13 23:53:01 2022
HL [00:00:00.367,614] <inf> fw_info: ------- DEBUG BUILD -------
HL [00:00:00.367,645] <inf> fw_info:
HEADSET left device
HL [00:00:00.378,234] <dbg> board_version: version_search: Board ver search OK!. ADC reg val: 1760
HL [00:00:00.378,234] <inf> board_version: Compatible board/HW version found: 1.0.0
HL [00:00:00.388,824] <dbg> board_version: version_search: Board ver search OK!. ADC reg val: 1774
HL [00:00:00.408,569] <inf> CS47L63: Tried to set supply, not supported
HL [00:00:00.429,321] <dbg> HW_CODEC: cs47l63_comm_reg_conf_write: Busy waiting instead of writing t3
HL [00:00:00.442,474] <wrn> bt_hci_core: Controller to host flow control not supported
HL [00:00:00.445,281] <dbg> ble: on_bt_ready: Bluetooth initialized
HL [00:00:00.571,197] <inf> ble: MAC: E1:28:5F:33:30:0E (random)
HL [00:00:00.571,411] <inf> ble: Controller version: 3251
HL [00:00:00.639,007] <dbg> HW_CODEC: cs47l63_comm_reg_conf_write: Busy waiting instead of writing t3
HL [00:00:00.640,899] <dbg> ble: iso_bis_rx_sync_get: Start scanning...
HL [00:00:00.642,517] <dbg> ble: iso_bis_rx_sync_get: Waiting for periodic advertising...
HL [00:00:00.649,505] <wrn> audio_datapath: I2S RX overrun. Single msg
HL [00:00:22.733,581] <inf> ble: Stop scanning...
HL [00:00:22.733,947] <dbg> ble: iso_bis_rx_sync_get: Creating Periodic Advertising Sync...
HL [00:00:22.735,870] <dbg> ble: iso_bis_rx_sync_get: Waiting for periodic sync
HL [00:00:22.975,860] <dbg> ble: iso_bis_rx_sync_get: Periodic sync established
HL [00:00:23.255,676] <dbg> ble: ble_trans_iso_init: Init finished
HL [00:00:23.255,767] <dbg> audio_datapath: audio_datapath_tone_play: Tone started
HL [00:00:23.255,798] <dbg> streamctrl: m_ble_transport_evt_handler: Received event = 0, current sta0
HL [00:00:23.255,798] <inf> streamctrl: BLE evt connected
HL [00:00:23.255,798] <dbg> streamctrl: m_ble_transport_evt_handler: Received event = 2, current sta1
HL [00:00:23.255,798] <inf> streamctrl: BLE evt link ready
HL [00:00:23.755,828] <dbg> audio_datapath: tone_stop_worker: Tone stopped
HL [00:00:41.946,838] <dbg> streamctrl: m_button_evt_handler: Got btn evt from queue - id = 4, actio0
HL [00:00:41.946,868] <dbg> ble: iso_bis_rx_sync_get: Already have sync, returning
HL [00:00:41.946,868] <dbg> ble: iso_bis_rx_start: Trying to get sync...
HL [00:00:42.017,181] <dbg> ble: iso_connected_cb: ISO Channel 0x20008f94 connected
HL [00:00:42.017,272] <dbg> ble: iso_bis_rx_start: bt_iso_big_sync established
HL [00:00:42.017,303] <dbg> streamctrl: m_button_evt_handler: Starting headset device
HL [00:00:42.017,303] <dbg> streamctrl: m_ble_transport_evt_handler: Received event = 3, current sta3
HL [00:00:42.017,303] <inf> streamctrl: BLE evt streaming
HL [00:00:42.018,981] <inf> audio_datapath: Drft comp state: CALIB
HL [00:00:42.019,958] <wrn> audio_datapath: Data received, total underruns: 2
HL [00:00:42.080,963] <wrn> audio_datapath: Data received, total underruns: 3
HL [00:00:42.118,957] <inf> audio_datapath: Drft comp state: OFFSET
HL [00:00:42.539,550] <inf> audio_datapath: Drft comp state: LOCKED
HL [00:00:42.548,370] <inf> audio_datapath: Pres comp state: MEAS
HL [00:00:42.658,355] <inf> audio_datapath: Pres comp state: WAIT
HL [00:00:42.658,386] <dbg> audio_datapath: audio_datapath_presentation_compensation: Presentation d6
HL [00:00:42.718,383] <inf> audio_datapath: Pres comp state: INIT
HL [00:00:42.729,278] <inf> audio_datapath: Pres comp state: MEAS
HL [00:00:42.838,378] <inf> audio_datapath: Pres comp state: LOCKED
HL [00:00:56.211,059] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [00:00:56.211,120] <wrn> sw_codec_select: PCM samples dropped
HL [00:00:56.211,120] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [00:16:03.624,053] <inf> audio_datapath: sdu_ref_us not from consecutive frames
HL [00:16:03.624,084] <inf> audio_datapath: Pres comp state: WAIT
HL [00:16:03.625,213] <wrn> audio_datapath: Data received, total underruns: 16
HL [00:16:03.674,072] <inf> audio_datapath: Pres comp state: INIT
HL [00:16:03.684,051] <inf> audio_datapath: Pres comp state: MEAS
HL [00:16:03.794,067] <inf> audio_datapath: Pres comp state: WAIT
HL [00:16:03.794,097] <dbg> audio_datapath: audio_datapath_presentation_compensation: Presentation d7
HL [00:16:03.854,064] <inf> audio_datapath: Pres comp state: INIT
HL [00:16:03.864,074] <inf> audio_datapath: Pres comp state: MEAS
HL [00:16:03.974,090] <inf> audio_datapath: Pres comp state: LOCKED
HL [00:38:08.592,712] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [00:38:08.592,773] <wrn> sw_codec_select: PCM samples dropped
HL [00:38:08.592,773] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [00:38:59.018,371] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [00:38:59.018,432] <wrn> sw_codec_select: PCM samples dropped
HL [00:38:59.018,432] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [00:59:01.947,601] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [00:59:01.947,662] <wrn> sw_codec_select: PCM samples dropped
HL [00:59:01.947,662] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [01:30:39.962,249] <wrn> audio_datapath: In I2S TX underrun condition, total: 5000
.....
HL [02:04:10.084,564] <wrn> audio_datapath: In I2S TX underrun condition, total: 2015000
HL [02:04:11.089,080] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [02:04:11.089,080] <inf> audio_datapath: sdu_ref_us not from consecutive frames
HL [02:04:11.089,111] <inf> audio_datapath: Pres comp state: WAIT
HL [02:04:11.089,141] <wrn> sw_codec_select: PCM samples dropped
HL [02:04:11.089,172] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [02:04:11.089,630] <wrn> audio_datapath: Data received, total underruns: 2016004
HL [02:04:11.184,661] <inf> audio_datapath: Drft comp state: OFFSET
HL [02:04:11.483,428] <inf> audio_datapath: Drft comp state: LOCKED
HL [02:04:15.094,573] <wrn> audio_datapath: In I2S TX underrun condition, total: 2020000
.....
HL [02:25:15.171,630] <wrn> audio_datapath: In I2S TX underrun condition, total: 3280000
HL [02:25:17.520,812] <inf> audio_datapath: sdu_ref_us not from consecutive frames
HL [02:25:17.521,789] <wrn> audio_datapath: Data received, total underruns: 3282349
HL [02:25:17.560,791] <inf> audio_datapath: Drft comp state: OFFSET
HL [02:25:17.560,852] <inf> audio_datapath: Pres comp state: INIT
HL [02:25:17.858,978] <inf> audio_datapath: Drft comp state: LOCKED
HL [02:25:17.860,809] <inf> audio_datapath: Pres comp state: MEAS
HL [02:25:17.970,825] <inf> audio_datapath: Pres comp state: WAIT
HL [02:25:17.970,825] <dbg> audio_datapath: audio_datapath_presentation_compensation: Presentation d7
HL [02:25:18.030,822] <inf> audio_datapath: Pres comp state: INIT
HL [02:25:18.040,832] <inf> audio_datapath: Pres comp state: MEAS
HL [02:25:18.150,817] <inf> audio_datapath: Pres comp state: LOCKED
HL [02:46:37.444,976] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [02:46:37.445,037] <wrn> sw_codec_select: PCM samples dropped
HL [02:46:37.445,037] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [03:32:09.018,737] <inf> audio_datapath: sdu_ref_us not from consecutive frames
HL [03:32:09.018,737] <inf> audio_datapath: Pres comp state: WAIT
HL [03:32:09.019,897] <wrn> audio_datapath: Data received, total underruns: 3282632
HL [03:32:09.068,725] <inf> audio_datapath: Pres comp state: INIT
HL [03:32:09.078,735] <inf> audio_datapath: Pres comp state: MEAS
HL [03:32:09.188,751] <inf> audio_datapath: Pres comp state: WAIT
HL [03:32:09.188,751] <dbg> audio_datapath: audio_datapath_presentation_compensation: Presentation d7
HL [03:32:09.248,748] <inf> audio_datapath: Pres comp state: INIT
HL [03:32:09.258,728] <inf> audio_datapath: Pres comp state: MEAS
HL [03:32:09.368,743] <inf> audio_datapath: Pres comp state: LOCKED
HL [03:39:28.005,126] <inf> audio_datapath: sdu_ref_us not from consecutive frames
HL [03:39:28.005,157] <inf> audio_datapath: Pres comp state: WAIT
HL [03:39:28.006,317] <wrn> audio_datapath: Data received, total underruns: 3282765
HL [03:39:28.055,145] <inf> audio_datapath: Pres comp state: INIT
HL [03:39:28.065,155] <inf> audio_datapath: Pres comp state: MEAS
HL [03:39:28.175,140] <inf> audio_datapath: Pres comp state: WAIT
HL [03:39:28.175,170] <dbg> audio_datapath: audio_datapath_presentation_compensation: Presentation d7
HL [03:39:28.235,168] <inf> audio_datapath: Pres comp state: INIT
HL [03:39:28.245,178] <inf> audio_datapath: Pres comp state: MEAS
HL [03:39:28.355,163] <inf> audio_datapath: Pres comp state: LOCKED
HL [03:46:18.599,792] <inf> audio_datapath: sdu_ref_us not from consecutive frames
HL [03:46:18.599,822] <inf> audio_datapath: Pres comp state: WAIT
HL [03:46:18.600,952] <wrn> audio_datapath: Data received, total underruns: 3282798
HL [03:46:18.649,810] <inf> audio_datapath: Pres comp state: INIT
HL [03:46:18.659,790] <inf> audio_datapath: Pres comp state: MEAS
HL [03:46:18.769,805] <inf> audio_datapath: Pres comp state: WAIT
HL [03:46:18.769,805] <dbg> audio_datapath: audio_datapath_presentation_compensation: Presentation d7
HL [03:46:18.829,803] <inf> audio_datapath: Pres comp state: INIT
HL [03:46:18.839,813] <inf> audio_datapath: Pres comp state: MEAS
HL [03:46:18.949,829] <inf> audio_datapath: Pres comp state: LOCKED
HL [04:01:11.272,827] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [04:01:11.272,888] <wrn> sw_codec_select: PCM samples dropped
HL [04:01:11.272,888] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [04:55:04.378,692] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [04:55:04.378,753] <wrn> sw_codec_select: PCM samples dropped
HL [04:55:04.378,753] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [04:55:04.828,735] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [04:55:04.828,796] <wrn> sw_codec_select: PCM samples dropped
HL [04:55:04.828,796] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [04:55:05.388,732] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [04:55:05.388,763] <wrn> sw_codec_select: PCM samples dropped
HL [04:55:05.388,793] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [04:55:06.148,773] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [04:55:06.148,834] <wrn> sw_codec_select: PCM samples dropped
HL [04:55:06.148,834] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [04:55:10.209,075] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [04:55:10.209,136] <wrn> sw_codec_select: PCM samples dropped
HL [04:55:10.209,136] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [06:40:45.324,523] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [06:40:45.324,584] <wrn> sw_codec_select: PCM samples dropped
HL [06:40:45.324,584] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame
HL [06:59:24.373,840] <dbg> audio_datapath: audio_datapath_stream_out: Bad audio frame
HL [06:59:24.373,901] <wrn> sw_codec_select: PCM samples dropped
HL [06:59:24.373,901] <wrn> audio_datapath: Wrong size of frame, mayge get a bad frame

maybe it useful for you

thanks

RE: Panic, when playing music

user87869 — Wed, 15 Jun 2022 19:10:52 GMT

Yes, that should suffice.

Let me know if you still experience this issue following the change!

Best regards,
Karl

RE: Panic, when playing music

user113636 — Wed, 15 Jun 2022 14:43:51 GMT

and i will replace line815 with following:

LOG_WRN("Wrong size of frame, mayge get a bad frame");

RE: Panic, when playing music

user113636 — Wed, 15 Jun 2022 14:31:33 GMT

Hi, Karl

i will testyour suggestion

thanks

RE: Panic, when playing music

user87869 — Wed, 15 Jun 2022 09:20:38 GMT

Hello again,

The behavior you describe in your ticket is something we have seen before when using the SBC codec. In essence, it is caused by sw_codec_select not handling the SBC's output properly when a bad frame occurs.
As a quick fix for this I suggest that you just remove the ERR_CHK_MSG on line 815 in this case - at worst this could sometimes produces audiable artifacts when a bad frame occurs with the SBC codec, since ctrl_blk.decoded_data contains the data from the last frame/package, which means that the same frame will be played twice.

Please try this, and let me know if it resolves the issue.

Best regards,
Karl

RE: Panic, when playing music

user113636 — Mon, 13 Jun 2022 13:10:07 GMT

i am sure i have remove that from both overlay-headset.conf and overlay-gateway.conf

thanks

RE: Panic, when playing music

user87869 — Mon, 13 Jun 2022 12:57:33 GMT

Hello,

It seems that the data received is reported as the wrong size, which causes the operation to cancel.
Have you made any other changes to the reference application than those you have listed at the beginning of your ticket?

I notice that you are using the SBC codec, could you confirm that you have also removed the following:

CONFIG_LC3_ENC_CHAN_MAX=2
CONFIG_LC3_DEC_CHAN_MAX=1

from overlay-headset.conf and overlay-gateway.conf?

As a side note I would also like to recommend that you use the LC3 codec for your evaluation if possible, since it significantly outperforms the SBC in all aspects for the common audio use-cases.

Best regards,
Karl

RE: Panic, when playing music

user113636 — Sat, 11 Jun 2022 14:33:03 GMT

and my nRF connect SDK version is 2.0.0